I took the Passat to the dealership so they could confirm the intercooler coolant leak and provide a repair estimate which was $1460+tax. They gave me the VW Customer Assistance hotline number so I could request assistance with the repair. The Passat was delivered in late August 2013 and has ~71k miles on it. Thanks. Edit: just after posting this I found this video: This explained a lot of things for me and I realise the best way to remove the EGR is together with the whole cooler from underneath the car. I'll have to find more info about this though. Last edited: Aug 1, 2022. How to clean an EGR valve | Tips from AUTODOCPoor quality fuel, oil in the engine combustion chambers, and improper air–fuel mixing cause contamination of th There is no performance issue at all. scanned the car and the code was stored P2002 something to do with Diesel Particulate Filter (DPF) Trap, Bank 1 - Efficiency Below Threshold/Malfunction it comes with Glowplug light flashing or sometimes with ENgine light. But there is no impact on car performance. **Check out the tools we used below. If the video was helpful, please give it a "thumbs up" and consider subscribing to the channel.**This video goes over ho hi, i have a caddy 1.6 tdi with EGR fault (when the fault indication light turned on i called RAC their diagnostic tool showed EGR valve frailer). The so called “fix” is no applied to the van yet. contacted VW on the phone they say it is not there problem and we have to pay for the repairs. i have not contacted the dealer ship yet. what 6tvh6T. P01012 000 - Signal too low. other than the engine management light the car runs absolutely fine. I probed the MAF plug and here are the results for a 5 pin BOSCH. plug. Engine off. Pin 01 - empty. Pin 02 - 0.05v. Pin 03 - battery voltage (fine) Remove both hoses pictured below (red arrow is for a later step, bleeding the coolant system). Attach a drain hose to one of the hoses and press a garden hose against the other. Once it's clean, flush it with distilled water. Then remove the oil cooler hose pictured above and flush it the same way as the heater core. Passat 2015 Max Performance Kit DPF,EGR & Adblue Delete (tuning required, not included) Increase the performance, reliability and fuel economy of your 2015 VW Passat TDI by eliminating the restrictive Diesel Particulate Filter (DPF), Exhaust Gas Recirculation (EGR) system, Adblue system, catalytic converters and factory muffler, thus allowing 3 Gas Recirculation Valve (egr Valve) problem Failure Date: 01/24/2014 I bought a 2013 Passat se may 16, 2013, it currently has 28,000 miles on it and I take very good care of it. 2 weeks ago I just started my trip to work (75 miles one way / 95% highway) when the glow plug indicator came on and I immediately lost most power. There is no performance issue at all. scanned the car and the code was stored P2002 something to do with Diesel Particulate Filter (DPF) Trap, Bank 1 - Efficiency Below Threshold/Malfunction it comes with Glowplug light flashing or sometimes with ENgine light. But there is no impact on car performance. EGR Valve Replacement: How to Clean, Bypass, and Replace a Bad EGR Valve // Looking to do an EGR valve replacement? This video will walk you through an EGR

how to clean egr valve vw passat 2.0 tdi